Baldor TS25 Owner's Manual Page 1

POW’R Lite Kit forTowable GeneratorsTS25 through TS80Installation & Operating Manual9/09 MN2421

3-2 Receiving & Installation MN2421Table 3-1 POW’R LITE Option DimensionsGenerator A (max) A1 (min) A2 (max) B CTS25 33’ 8” 11’ 5−1/2” 92.20 1

Receiving & Installation 3-3MN2421TS25/35 Control Box & Mast SupportFigure 3-3 TS25/35 Mast Support Installation Mast SupportBracketControl

3-4 Receiving & InstallationMN2421Figure 3-4 TS45/60/80 Mast Support Installation Mast Anchor (2)1/2−13 x 5.5”Control BoxDetail ViewU-Bolt1/2” x

Receiving & Installation 3-5MN2421The POW’R LITE assembly Continued8. Remove the cotter pin, washer and pin from the Winch Cable Tie Point of the

3-6 Receiving & InstallationMN24213. Connect the following POW’R LITE cable wires, see Figure 3-6:a. Yellow wire to 1st terminal (Top).b. Brown t

Receiving & Installation 3-7MN2421Installation of TS45/60/80 Electric WinchSince the TS45/60/80 is so tall, the lift winch is an electric winch t

3-8 Receiving & InstallationMN24218. Connect the Lift Winch Motor Switch as shown in Figure 3-9. (The + Battery connectioncan be made at the sole

Section 4OperationOperation 4-1MN2421Light Tower SetupWARNING: The mast assembly must remain in the stowed position until the outriggers are properly

4-2 Operation MN2421Light Tower Setup Continued1. With the Light Mast in its’ stowed position, install or reposition the four light fixtures tothe d

Section 5Troubleshooting and MaintenanceTroubleshooting and Maintenance 5-1MN2421Flood Light Bulb ReplacementWARNING: Light fixtures become extremely

Any trademarks used in this manual are the property of their respective owners. WARNING:CALIFORNIA PROPOSITION 65 WARNING:Engine exhaust from this pro

5-2 Troubleshooting and Maintenance MN2421Figure 5-1 POW’R LITE Connection Diagram BlackRedGreen

Baldor District Offices

WARNING:CALIFORNIA PROPOSITION 65 WARNING:Engine exhaust from this product contains chemicals knownto the state of California to cause cancer, birth

Table of ContentsTable of Contents iMN2421Section 1Product Safety Information 1−1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

ii Table of Contents MN2421

Section 1Product Safety InformationProduct Safety Information 1-1MN2421This kit can be installed on several models of the Baldor Towable Generators.

1-2 Product Safety Information MN2421WARNING: Never attempt to move the POW’R LITE when the mast is in the vertical position. AllOutrigger and traile

Section 2General InformationGeneral Information 2-1MN2421Thank you for purchasing your POW’R LITE Kit. This manual contains information you need to

2-2 General Information MN2421

Section 3Receiving & InstallationReceiving & Installation 3-1MN2421Receiving & Inspection When you receive your generator, there are sev